Wednesday 18 November 2015

Enfield 350 - Touring Two-Up with Heavy Luggage - Lessons Learnt

Hey there,

if you are reading this post, either you own/have owned a 350 single (highly likely, if you own an Enfield) or are curious to know what the challenges faced by most Enfield 350 riders are while doing long-distance trips with a pillion and heavy luggage. Instead of generalizing this experience, let's consider the bike I ride on my tours, as a case in point. 


During the Leh Tour in 2014

For starters here are the engine specs of the (factory stock) Electra 5s cast-iron model.

Engine Specs: Royal Enfield Electra 5s (2009 model)


Information Courtesy: www.enfieldmotorcycles.in

Kerb Weight: Royal Enfield Electra 5s (2009 model)


Information Courtesy: www.ibikes.in

Now my bike has gone a few steps beyond being stock, in the form of modifications for touring, which adds to the weight of the bike. For example an expanded fuel tank with a usable capacity of 19ltrs, handlebars with the center rod, larger split bucket seats, rear crash bars, saddle bag support frame, fog lamps, rear luggage carrier, lever guards, 3.50 off-road tire at the back and additional on-bike tools in the kit.

The increase in weight (and size), due to these mods is quite a bit, though I never bothered to measure how much the increase in weight is. Now my steed also runs with a bigger size piston than the stock and carbs have been re-jetted. This project I had to stop halfway through due to lack of time/spares and may complete this sometime in the future with the addition of a free-flowing exhaust and maybe a bigger carb (machismo A350 ?!!). But then that would be part of another post. Now let's get back to the subject of two up touring on this 350 single.


Past experiences of riding two-up:

During the last few years of my ownership of this bike, I have ridden it extensively over longer distances, and 90% of the time, my luggage setup looked like this: a pair of saddle bags, a tank bag, and possibly a tent/tripod or some other form of weight at the back.

During a trip around Kerala in 2015

For longish trips, I mostly ride solo. However few times I have ridden with a pillion at the back. Among such rides, the ones worth a mention are as follows:


Observations during the Recent two-up trip (1600+ KMs):

During solo rides, with my usual luggage setup, the bike never really struggled in any kind of terrain or surface. Well, except while climbing a few tough patches off of Khardung-La, during the Leh-Ladakh Tour last year. This was due to obvious reasons like higher altitude (i.e. reduced oxygen density for the fuel to burn). This time, however, I had to load my saddle bags with more stuff than just for the trip, as I was going home for the vacation. For instance my laptop I had to carry my, which itself is 2+ kilos of weight, and then pair of extra shoes and the list goes on and on. In isolation, they look like small items each, whose weight shouldn't be a concern, but by the time you are done stuffing those two measly saddlebags, try lifting them to know. Now let me share the recent challenges I faced while the bike was a bit overloaded with heavy luggage and a pillion, on fairly good roads (NH5?!).

Cons:
  1. The bike was revving harder (high rpm/throttle twist) from the get-go, all the way to 90 KPH (i.e. engine remains stressed all through)
  2. Vibration on the handlebars was higher due to a high-revving engine
  3. Braking distance was higher due to a substantial increase in the weight
  4. Braking hard (say in an emergency), putting pressure on fork and cone (T-joint) set, I could hear the noise
  5. In usual mud puddles, where I used to come out in a snap, tires dug in deeper (due to the weight of course) and made handling the bike a challenge
  6. Top speed hovered around 80-90, no matter how good the road was

A bike loaded beyond the standard luggage weight (plus a heavy pillion) had very few pros that I could recall, namely:
  1. The bike felt very stable at high speeds on the highways
  2. The bike felt planted while cornering
  3. Surprisingly tires were holding up the road better (than when I rode solo), and during a stretch, we rode in heavy rain (this I can't confirm as a fact as of now)

Now on the surface, 'cons' are obvious ones and mostly resulting due to the substantial increase in weight. However, the following are some of the consequences of the cons:

After around 200-300 KMs of traveling, I did a quick check on the fuel economy and was surprised to know that it was giving 21-22 (normally it gives well above 30 KM/Ltr). I did a quick check on the engine oil and my suspicion was true. While we were happy doing 90 KPH for the better part of the day, the bike had burnt a lot of engine oil. Had I ignored this condition for another few hours, there was a high chance of an engine seizure. Thanks to my pillion who wanted to know the fuel economy, for which I had to check and as a result did an oil level check. Otherwise, also I keep an eye on the engine from time to time. These are not really an issue with the modern breed of bikes with aluminum engines and liquid cooling (or even new air-cooled ones). Engines have undergone years of technological evolution to reach here and nowadays all a rider needs to check is the warning lights on the console, which will tell you when your engine is overheating and much more valuable information. For us who still own/ride vintage (if I may), air-cooled, single-cylinder British bikes (though made in India now), we have no other choice but to be vigilant, especially when doing distances like 1000 km. And mind you, I am not complaining at all. The experience I have gained dealing with my iron horse, I wouldn't trade it for anything in this world (not even for a brand new BMW GS800.. or so to speak).

So if you have to ride two up, here are a few things I suggest (and would be following myself for my future rides).


Before Ride: (motorcycle)
  • Buy and keep, 1 liter of extra engine oil (I always carry a can in my saddle bags) 
  • Check engine oil (lubricant) level and keep it possibly a little* over the usual mark (top-up from your new bottle?!!)
  • Check chains and sprockets and replace them as necessary. If the sprocket teeth in the last stage of the chain are unevenly saggy even after tightening, they may give up halfway due to the extra load.
  • Pack light, i.e. keeps the luggage weight to a minimum (Note: I didn't have a choice this time), cause your pillion may not be able to lose weight for your bike's sake :). At least in my case, he didn't. :/
  • Carry a spare clutch cable, as depending on your riding style, you may stress it more while moving from a standstill,  as your bike will be pulling a lot of weight. Glad we had less riding in traffic, so this didn't cause any issues.


During Ride: (motorcycle)
  • Pay attention to the revs (rpm) while riding and ensure that the engine is not constantly being stressed (not good!).
  • While trying to catch up speed, do it slowly ensuring the bike is gaining momentum without the engine screaming for breath (No 0-60 please, unless you want to brick your engine!).
  • Give your engine a break to cool down (say every 100 KMs or as you feel right).
  • Check your engine oil level every 200-300 KMs as a thumb rule. In addition to that, do check the oil level, when you feel that the engine is struggling (e.g. overheating, too much vibration, loss of power, low fuel economy, etc).
  • Keep a watch on your fuel consumption, as the engine is stressed, it is meant to burn more fuel. However, if it's burning fuel way more than expected (like in my case it did on the first day), then check for possible issues.

During Ride: (rider)
  • Drink more water (& more frequently) than you think you need. You are managing a bike much heavier than you usually ride, so along with the bike, you to are being exposed to stress and vibrations. So stay hydrated, period!).
  • On dual carriage roads (2-way traffic), have extra space (than you usually would) in the front while overtaking, as the bike's response to throttle would be lethargic and you would need more time to complete the overtake before you come close to a vehicle in coming from the opposite direction (scary stuff!).
  • Keep more distance from the vehicle in the front, for the same reason that you are fat and heavy and you would need more time and space to stop safely in an emergency. If the vehicle in front chooses to brake hard, you would have enough time and space to bring your mammoth to a halt safely.


I am hoping you too have just one bike and when the opportunity comes to share the ride with a friend, your choices will be limited, like mine. Then again, it's always a pleasure to share the journey, isn't it ?!! Honestly, I can live with the cons of riding heavy/underpowered in return for a great company. So all we need to do is mitigate the risks/impacts and prepare well for a stress-free ride, for the most part for the motorcycle and to some extent for the rider. Hope this post helps you do better two-up rides while keeping your bike happy at the same time.

If you found this post useful, feel free to comment/share/subscribe.


Cheers!!

Sid

6 comments:

Ash Green said...

Wow :)
This is an incredible collection of ideas!
Waiting for more helpful pieces.
You would amazing to read a similar one here-
the motorbiker

SpacioBiker said...

Eu entendi exatamente o que você quis dizer, obrigado por postar. nós fornecemos acessórios a um custo acessível. para mais informações visite nosso website Spaciobiker

tike mik said...

One in ten women will get breast cancer in their lifetime. Virtually every adult knows of someone who has breast cancer or has died from breast cancer. October has become breast cancer awareness month and it is the single biggest fundraising month for finding a cure for breast cancer. Click here for more details

David Townsend said...

Nice Informative Blog having nice sharing.. Ladakh motorbike tours

cash4motorcycle said...

I am very grateful that I found some helpful content during this post. After reading it, I feel that you simply have good knowledge. Thanks for posting it. Keep it up.sell my motorcycle

royalbabywholesale said...

I found decent information in your article. I am impressed with how nicely you described this subject, It is a gainful article for us. Thanks for share it. 12 Inch Princess Kids Bike Online Usa